Journal of Aerospace Science and Technology

Journal of Aerospace Science and Technology

CFD analysis and thermodynamic modeling of gas behavior in liquid engine tanks

Document Type : Original Article

Authors
Department of Mechanical Engineering, Qom University of Technology, Qom, Iran
Abstract
This study investigates the gas behavior within the propellant tanks of a pressurization system. A time-dependent thermodynamic model was developed to analyze the variations in gas properties, including pressure, temperature, and density, throughout the operation of the propulsion system. Additionally, the behavior of the gas and liquid inside the tank during engine operation was numerically simulated using the Fluent CFD package. The simulation employed the Volume of Fluid (VOF) model and the Standard k-ε turbulence model to resolve the turbulent two-phase flow in the tank. The numerical results for the gas phase obtained from the CFD simulation were compared with the thermodynamic model, demonstrating good agreement between the two approaches. The maximum discrepancy between the results was found to be less than 10%, for both pressure and temperature, and for both upper and lower tanks. While the thermodynamic model is effective for analyzing the average gas behavior over the system's operational duration, the CFD analysis provides detailed insights into the flow dynamics. This combination of approaches offers a comprehensive understanding of the system's performance.
Keywords

Subjects


[1]    S. In, S. Jeong, and H. Kim, “Investigation on liquid helium pressurization process using a heater in a liquid propellant rocket,” Cryogenics, vol. 44 , no. 6-8, pp. 467–474, 2004, https://doi.org/10.1016/j.cryogenics.2004.02.010 .
[2]    P. Adnani and R. Jennings, “Pressurization analysis of cryogenic propulsion systems,” in 36th AIAA/ASME/SAE/ASEE Joint Propulsion Conference and Exhibit, Las Vegas, NV, USA, 2000, Paper AIAA-2000-3788, https://doi.org/10.2514/6.2000-3788.
[3]    C. Borgnakke, R. E. Sonntag, Fundamentals of Thermodynamics, 7th ed, John Wiley & Sons, 2009.
[4]    A. Majumdar, J. Valenzuela, A. LeClair, and J. Moder, “Numerical modeling of self-pressurization and pressure control by a thermodynamic vent system in a cryogenic tank,” Cryogenics, vol. 74, pp. 113-122, 2016, https://doi.org/10.1016/j.cryogenics.2015.12.001.
[5]    G. Zilliac and M. Karabeyoglu, “Modeling of propellant tank pressurization,” in 41st AIAA/ASME/SAE/ASEE Joint Propulsion Conference & Exhibit, Tucson, Arizona, 2005, Paper AIAA 2005-3549, https://doi.org/10.2514/6.2005-3549.
[6]    J. Li, G. Liang, P. Zhu, and X. Wang, “Numerical investigation of the operating process of the liquid hydrogen tank under gaseous hydrogen pressurization,” Aerospace Science and Technology, vol. 93, 2019, Art. no. 105327, https://doi.org/10.1016/j.ast.2019.105327.
[7]    H. Karimi, A. Nassirharand, and M. Mohseni, “Modeling and simulation of a class of liquid propellant engine pressurization systems,” Acta Astronautica, vol. 66, no. 3-4, pp. 539-549, 2010, https://doi.org/10.1016/j.actaastro.2009.07.018.
[8]    J. Li and G. Liang, “Simulation of mass and heat transfer in liquid hydrogen tanks during pressurizing,” Chinese Journal of Aeronautics, vol. 32, no. 9, pp. 2068–2084, 2019, https://doi.org/10.1016/j.cja.2019.05.008.
[9]    M. Gierasa and A. Gorgeri, “Numerical modelling of the hybrid rocket engine performance,” Propulsion and Power Research, vol. 10, no. 1, pp. 15-22, 2021, https://doi.org/10.1016/j.jppr.2021.03.001.
[10]    L. Wang, Y. Li, C. Li, and Z. Zhao, “CFD investigation of thermal and pressurization performance in LH2 tank during discharge,” Cryogenics, vol. 57, pp. 63–73, 2013, https://doi.org/10.1016/j.cryogenics.2013.05.005.
[11]    Z. Zuo, W. Jiang, X. Qin, and Y. Huang, “A numerical model for liquid–vapor transition in self-pressurized cryogenic containers,” Applied Thermal Engineering, vol. 193, 2021, Art. no. 117005, https://doi.org/10.1016/j.applthermaleng.2021.117005.
[12]    W. Lei, M. Yuan, W. Ying, X. Fushou, and L. Yanzhong, “Investigation on pressurization behaviors of two-side-insulated cryogenic tank during discharge,” International Journal of Heat and Mass Transfer, vol. 102, pp. 703–712, 2016, https://doi.org/10.1016/j.ijheatmasstransfer.2016.06.045.
[13]    L. Wang, Y. Li, Z. Zhao, and Z. Liu, “Transient thermal and pressurization performance of LO2 tank during helium pressurization combined with outside aerodynamic heating,” International Journal of Heat and Mass Transfer, vol. 62, pp. 263–271, 2013, https://doi.org/10.1016/j.ijheatmasstransfer.2013.03.021.
[14]    Y. Mitikov, O. Shynkarenko, “Reduction of the Pressurization System Final Mass for a Modern Rocket Launcher,” Journal of Aerospace Technology and Management, vol. 14, 2022, Art. no. e0122, https://doi.org/10.1590/jatm.v14.1238.
[15]    S. Barsi and M. Kassemi, “Numerical and experimental comparisons of the self-pressurization behavior of an LH2 tank in normal gravity,” Cryogenics, vol. 48, no. 3-4, pp. 122–129, 2008, https://doi.org/10.1016/j.cryogenics.2008.01.003.
[16]    C. H. Panzarella and M. Kassemi, “Self-pressurization of large spherical cryogenic tank in space,” Journal of Spacecraft and Rockets, vol. 42, no. 2, pp. 299-308, 2005, https://doi.org/10.2514/1.4571.
[17]    D. A. Fester, “Main tank injection (mti) pressurization of liquid rocket propellant tanks,” in 54th International Astronautical Congress of the International Astronautical Federation, the International Academy of Astronautics, and the International Institute of Space Law, Bremen, Germany, 2003, Paper IAC-03-IAA0203006, https://doi.org/10.2514/6.IAC-03-IAA.2.3.06.
[18]    L. C. Yang, “Relevant mechanisms affecting the efficiency in detonation of energetic gaseous mixtures”. in AIAA SCITECH 2024 Forum, Orlando, FL, 2024, Paper AIAA 2024-2161, https://doi.org/10.2514/6.2024-2161.
[19]    R. Scholl, D. Freudenmann, and S. Schlechtriem, “Microencapsulation of hydrocarbon fuels for monopropellant creation with hydrogen peroxide,” Fuel, vol. 356, 2024, Art. no. 129520, https://doi.org/10.1016/j.fuel.2023.129520.
[20]    S. Ali, N. Abbas, S. A. Khan, I. Malik, and M. Mansha, “Chemical-based hydrogen storage systems: Recent developments, challenges, and prospectives,” Chemistry – An Asian Journal, vol. 19, no. 16, 2024, Art. no. e202400320, https://doi.org/10.1002/asia.202400320.
[21]    L. Yin, H. Yang, and Y. Ju, “Review on the key technologies and future development of insulation structure for liquid hydrogen storage tanks,” International Journal of Hydrogen Energy, vol. 57, pp. 1302–1315, 2024, https://doi.org/10.1016/j.ijhydene.2024.01.093.
[22]    W. Fan, Y. Ding, and Z. Xiao, “A brand new green coating technology for realizing the regulation of spherical propellant energy release process,” Defence Technology, vol. 36, pp. 78–94, 2024, https://doi.org/10.1016/j.dt.2024.02.008.
[23]    Y. A. Cengel, M. A. Boles, M. Kanoglu, Thermodynamics: An Engineering Approach, 9th ed., McGraw-Hill, 2018. 
[24]    G. F. Pinder, Numerical Methods for Solving Partial Differential Equations: A Comprehensive Introduction for Scientists and Engineers, 1 st ed. John Wiley & Sons, Inc., 2018.
[25]    FLUENT 6.1 User’s Manual, Copyright 2003 by Fluent Inc.  
[26]    H. K. Versteeg and W. Malalasekera, An Introduction to Computational Fluid Dynamics, The Finite Volume Method, 2nd ed., Pearson Education Limited, 2007.
[27]    M. Mohseni, and M. K. Domfeh, “Numerical analysis of transient vortex formation at the outlet of a tank containing gas-liquid phases,” Journal of Applied Fluid Mechanics, vol. 16, no. 11, pp. 2235-2248, 2023, https://doi.org/10.47176/jafm.16.11.1942
Volume 18, Issue 1
2025
Pages 108-120

  • Receive Date 16 July 2024
  • Revise Date 02 February 2025
  • Accept Date 25 February 2025
  • First Publish Date 01 April 2025